Thanks Blue, I was slightly concerned for about a minute, but as Pete will have guessed I've already bolted it all together
I Scotchbrited the faces and thoroughly de-greased and cleaned everything.
I had to drill and tap one bellhousing bolt-hole 1/2" deeper as the threads were knackered.
I took the reverse light switch out to replace the fibre washer and realised it was also leaking THROUGH the switch- I cleaned out the recesses around the connector blades and filled em with araldite.
New fluid in and the clutch & gearbox are done
While the car's up I figured I'd do the oil and filter too. As it's also leaking slightly I dropped the sump. An easy job on my car- just loosen the steering rack and drop one end and off comes the pan
Nothing nasty in there so I gave it a good clean and flattened the flanges a bit. The end seals are split so I couldn't just re-fit it and I left it too late to order gaskets for tomorrow so the car will be laid up til Monday now A frustrating waste of 3 days potential tuning-time
Posted: Thu Jul 18, 13 11:15 pm
by db
Just added 1/2" preload to the front shocks, lets see if that stops it bottoming out in potholes
While under there I noticed a loose disc bolt
All out, Loctited and cranked up tight
Posted: Sat Jul 20, 13 12:02 am
by db
Today's tinkering involved finding out a sump gasket set would sting me £50 if want it before the end of next week
I've cleaned up the old ones and plenty of good quality silicone... sorted!
Full harness is in, including the removable centre bar.
I made a box to protect the fuel pump etc from all the crap I'll be taking to the Pod... and stuck on me race numbers
Posted: Sat Jul 20, 13 12:16 am
by Mossy68
Love your car. And this thread.
Full stop !
Posted: Sat Jul 20, 13 1:24 pm
by db
Just putting the exhausts back on this morning and the bloody reverse switch is leaking AGAIN!!
Anyone got a spare?
Posted: Sat Jul 20, 13 7:22 pm
by db
Switch innards ripped out & filled with Araldite.
Fluid back in.
8 litres of new 10/40 Morris's engine oil, new filter on.
Car back on it's wheels again, ready for tuning
Posted: Sun Jul 21, 13 2:50 pm
by db
Just back from 1st sesh, didn't get far
NO idle circuit, AFR 20, idle mix screws have no effect, neither does fiddling with pri or sec throttle stop screws.
Ade went through possible causes with me, we reckon most likely cause is a blockage or a leak in the primary idle area.
Gonna take carb off now & check it over again.
Also clutch barely releasing so I'll adjust it up a bit.
More later....
Posted: Sun Jul 21, 13 11:28 pm
by db
Getting much better now.
I checked the timing, initial is unchanged at 22, max is 35.
On Ade's advice I've re-connected the vac advance, though without help I've not been able to check what that's done to the timing.
I've played around with jets and then pump cams and at times it pulled incredibly well!
If can just pin down the right combo she's gonna fly!
Just found this very helpful vid-
Posted: Tue Jul 23, 13 3:49 pm
by db
Well last nights tuning session was mostly a frustrating waste of an evening and a heap of petrol! I got home still with a massive off-idle hole which just seemed if anything to be getting worse!
Luckily a mate I'd not seen in ages (happens to be a pro mechanic) was just passing and spotted the car. I bored him with my woes and he only sussed a new fault- the primary pump ball check valve not seating properly.
Pressing the accelerator slowly as in mild acceleration just pushed fuel back into the float bowl so bugger-all came out of the shooters!! This would also have delayed the shot on harder acceleration.
I've gone back to the 750 vac float bowl for now, I'll fix that another day.
Well I'll have help tonight so I've big hopes!!
Posted: Wed Jul 24, 13 12:07 am
by db
YEAH!!!!
Running like a dream
My mate Gegs (he's coming with me to the Nats) came out and helped me stay focussed and we got the carb fully dialled in.
It now revs cleanly right through the rev range and goes like stink!!
I'm sure there's room for some fine tuning but it's pretty damn close now
We ended up with 72 primary, 80 secondary. EXACTLY what Les said about 15 pages ago
I've been gathering stuff to take, not sure what I'm gonna do with it all once we're there tho...
Posted: Wed Jul 24, 13 12:13 am
by Rebel
you forgot the beer Paul
Posted: Wed Jul 24, 13 7:20 am
by db
I'm such a lightweight mate, half a dozen cans will wipe me out for the weekend!
Posted: Wed Jul 24, 13 10:19 am
by charger01
Dont forget your AA card.
Posted: Wed Jul 24, 13 8:04 pm
by db
Posted: Thu Jul 25, 13 11:02 am
by sinny
Top stuff Paul! All the hard work is now going to pay off mate.
A frustrating waste of 3 days potential tuning-time 
